AIS10-25SXT Air Injection Iron, Sulfur, and Manganese Removal Oxidizing Water Filter for Whole House Filtration

Iron, sulfur, manganese all cause staining and odor issues. All of these problems can be eliminated with Oceanic Water System's Air Injection System (AIO). 

Using the principle of oxidation the system forces the contaminates into contact with oxygen. Most older air injection systems consist of either two separate tanks or by using a Venturi valve to inject air into the water. cleaned and/or replaced. By utilizing a patented piston our Air Injection system is able to put the whole oxidation process inside one tank keeping maintenance costs and down time to a minimum. This is done by creating a bubble of pressurized air at the top of the tank (done during the backwash cycle). The air in the tank then oxidized the contaminates with the media trapping them. Then every few days the system automatically backwashes itself rinsing the contaminates off of the media and replenishing the air bubble. 

This system is chemical free and is able to remove higher contaminate levels than most other tank systems on the market. Using an iron trapping media combined with air injection you remove the most iron sulfur and manganese problems without worrying about dangerous chemicals. 

Complete system includes: 

10" x 54" FRP Tank (Black or Almond) 

Riser Tube (pre-installed)

Control head 

1 cubic ft Media (Pre-filled for easy installation)

1" Bypass Valve (Can request ¾" by messaging or calling us)

- Service Rate: up to 7 GPM

- Peak Flow Rate (<10 minutes): 10 GPM

- Backwash Flow Rate (min required): 7 GPM

Single Tank Design

By creating a pocket of air at the top of the tank, the treatment process takes place in a single tank. This eliminates the need for a separate tank or pump and reduces wear on the system by removing the contaminants immediately after oxidation.

5600SXT Air Injection Control

Automatic backwashing digital SXT controller on the dependable 5600 valve provides ease of use and low maintenance. Specially setup for air injection to add air without a separate pump.

Filter media for trapping the iron and sulfur

The filter media in the tank traps the oxidized iron and sulfur until it is washed down the drain during the backwash cycle. The filter media will last 5 years on average and is easy to change when needed. Other filter media can be used for specific applications if needed in the future.

Complete System:

Complete system includes the tank, media, riser with distributor, 5600SXT Air Injection head, and bypass valve.

Note: Tank color may vary.